Question When to replace Chassis batteries?

[Neal]

On Sunday, on start up, I noticed on my dash a brief message LOW VOLTAGE!

Common and nothing to worry about. It's the huge voltage spike causing this and just how the FL dash is programmed when they should have coded that out.

 

[J&JD]

I could have spoken too soon?
On Sunday, on start up, I noticed on my dash a brief message LOW VOLTAGE! Did not see it the next 3 days. So I’m thinking that was the 3rd start that morning, and it may have brought the batteries a bit low? Will keep an eye on them more closely.

I get that all the time. Drives me nuts even though I know to ignore it.

 

[Buly]

I get that all the time. Drives me nuts even though I know to ignore it.

I feel better now ? thanks

 

[Rod]

Because of that thread, I asked Spartan to check if they were low and the techs advised against breaking the seal and checking. I had also been told Big Mike was telling participants in the Owners Class to do this and again the techs said no and were going to tell him to stop advising people to break seal. So instead I had them load test the batteries.

The electrolyte level in wet cell batteries does go down over time, even in the so called "sealed" wet cells. From the sealed batteries I have used over the years, "sealed" simply means harder to get into. No screw off or elevated filler caps, so the caps have to be pried off using a wide screwdriver, usually two caps, each covering three holes. I have never seen "a seal".

So we have one of two choices to make:

1.) Don't check the electrolyte and hope everything is ok. First couple of years should be fine depending on use and ambient temps. At some point however, the electrolyte most likely will get too low and then you have to replace the batteries. Once a year checks can prevent this.
2.) Check the electrolyte and rest assured that issue is not going to be the cause of bad chassis batteries.